环氧地坪翻新案例

发布日期:2019-06-24 浏览次数:195

环氧地坪漆常被用于工业场所,供叉车等行驶,还需要承受重压,虽然说环氧地坪在正常使用状态下可以使用5~8年,但是在使用过程中,常会出现一些问题,下面根据环氧地坪表面破损和污染的情况进行翻新方案的设计。环氧地坪的翻新不能一概而论,要根据实际情况制定相应的施工方案,合理利用资源。

Epoxy floor paint is often used in industrial sites, forklift trucks and other driving, but also need to bear heavy pressure. Although the epoxy floor can be used for 5 to 8 years in normal use, but in the use process, there are often some problems. Below is the design of a new scheme based on the damage and pollution of the surface of the epoxy floor. The renovation of epoxy flooring can not be generalized. It is necessary to formulate the corresponding construction plan according to the actual situation and make rational use of resources.一、环氧地坪表面破损。

  1. The surface of epoxy floor is damaged.


首先检查一下环氧地坪破损的原因,如果是因为基层强度不够、受潮而导致的破损则应选择混凝土密封固化剂进行地面翻新,增强地面的强度。如果是因为在地坪施工的问题导致环氧地坪漆破损的,只需要将原来的地坪漆除掉重新上材料施工即可。

First, check the reasons for the damage of epoxy floor. If the damage is caused by insufficient strength of the base and damp, the concrete sealant should be selected for the ground renovation to enhance the strength of the ground. If the epoxy floor paint is damaged due to the problem of floor construction, only need to remove the original floor paint and restore the material for construction.

二、环氧地坪表面油污污染。

2. Oil pollution on the surface of epoxy floor.

如果地面受油污污染比较严重,且油渍已经渗入地里,无法清除的地面,建议重新浇筑混凝土地面或是使用混凝土密封固化剂加金刚砂耐磨地坪面层做处理。有油渍的地面容易造成环氧地坪漆脱层,所以要处理好。

If the ground is seriously polluted by oil, and the oil stain has infiltrated into the ground and can not be removed, it is recommended to re-pour the concrete floor or use concrete sealing and curing agent and diamond sand wear-resistant floor surface layer for treatment. Oil-stained ground can easily cause delamination of epoxy floor paint, so it should be handled properly.

三、对于旧地面。

3. For the old ground.

一些旧地面没有明显的刮痕和破损,只是装饰效果较差,可以选择环氧地坪漆进行施工;如果旧地面出现起尘起砂的情况且对美观性要求不高的,可以使用混凝土密封固化剂;如果要求地面美观,且耐磨、耐压、抗冲击的话可以选择水磨加混凝土密封固化剂。

Some old floors do not have obvious scratches and damages, but the decorative effect is poor, epoxy floor paint can be chosen for construction; if dust and sand occur on the old floors and the aesthetic requirements are not high, concrete sealing curing agent can be used; if the ground is beautiful, and wear-resistant, pressure-resistant, impact-resistant, water-abrasion and concrete sealing curing agent can be selected.

四、对于地面破损严重的,且有坑洞和裂缝的情况。

4. For serious ground damage, with pits and cracks.

地面坑洞较多,则不建议使用环氧地坪漆材料,因为材料用量会增加,成本也会加大。并且,地面有裂纹,如果再施工环氧地坪则会二次裂开。针对这一类型的地面建议,重新浇筑混凝土然后再施工金刚砂耐磨地坪面层或是混凝土密封固化剂。在地坪施工之前需要将原有地面清理干净,有必要的还需要打磨,然后再施工,这样才能保证地坪的使用年限。

The use of epoxy floor paint is not recommended because there are many pits on the ground, because the amount of material will increase and the cost will increase. Moreover, there are cracks on the ground. If the epoxy floor is re-constructed, it will split again. In view of this type of ground proposal, re-pouring concrete and then construction of diamond abrasion-resistant floor or concrete sealant curing agent. Before the construction of the floor, the original ground needs to be cleaned up and polished, and then the construction, so as to ensure the service life of the floor. 


辛苦整理!转载请注明来自 http://www.pengs888.com/show.asp?id=122

你觉得这篇环氧地坪翻新案例文章怎么样?

0 0
在线咨询
微信咨询
联系电话
13771445261
返回顶部